The Ford F250 4-speed 4R100 and 5-speed 5R110W and 6-speed 6R140 were able to handle the monster torque of the
6.0L and 7.3L Power Stroke Diesel engine, while providing impressive fuel economy. But they aren’t without their problems though, so let’s look at some of the most common Ford F250 Super Duty transmission problems, and figure out what you can do about them. Need a replacement transmission? Get an estimate for replacement transmissions and local installation. Look up your transmission model by vehicle make and model. Ford F250 Transmission Models1999-2004 Ford F250 Super-Duty: 4R100 Transmission Ford F250 Transmission Replacement Cost EstimateThese are the most current prices for a remanufactured replacement Ford F250 transmission. Replacement Ford F250 Transmission:
What are the DTC codes related to Ford F-250 transmission problems?
Tow/Haul Light Flashing – A flashing Tow Haul light on the Ford F-250 Super Duty acts as sort of a warning light to let you know that something is wrong with your 5R110W transmission. It can be as simple as a failed temperature sensor, or the valve body could be cracked in half. But you won’t know unless there was a DTC stored in the computer. Ford F-250 Transmission Recalls:Recall ID 07V139000 / 07S49 – Ford 5R110W Transmission 2008 Ford F250 6.4L Powerstroke diesel / 5R110W – Summary – Consequence – Solution Ford F250 Transmission Technical Service Bulletins | TSBsTSB 02–21–1 – 4R100 Transmission – Torque converter access plug may become dislodged TSB 98-20-9 – Ticking noise on initial startup when the selector is in park or neutral – 4R100 Transmission TSB 08-26-4 – 5R110W transmission failure in cold weather 05-25-4: 2005-2006 Ford Super Duty
6.0L – Some models equipped with the 5R110W transmission may experience erratic shifting in Tow/Haul Mode, a late 5-6 shift in Tow/Haul Mode, a harsh 3-2 engine braking downshift, and potentially a harsh 5-2 downshift. TSB 11-7-10 – 2-3 shift flare with P0733 DTC and or delayed reverse engagement – 6R140 transmission TSB 16-0057 – P0751, P0730 and/or P2700 DTCs – 6R140 Torqshift 6 Transmission & 5R110W Torqshift 5 Transmission Common Problems with the F250 4R100 Transmission (1999-2004)1) Faulty Shift Solenoids Heat and vibration are the natural enemy of car parts, and they’re the main cause of premature solenoid failure on the Ford 4R100 transmission. These little plunger mechanisms route pressurized ATF through the valve body to actuate a shift. Over time, the heat and vibration can short out the wiring on a 4R100 solenoid, leading to delayed shifts, or no shift at all. 2) Failed Forward Clutch Drum Controlling hydraulic pressure is the key to creating a durable transmission. Unfortunately, an OE design flaw in the accumulator pistons and snap ring can cause the 4R100 forward clutch drum to fail prematurely. Leading to no forward gears, or severe slipping in 1st, 2nd, or 3rd gears. To solve this problem, each SST remanufactured 4R100 transmission gets upgraded (see: Stronger) 1-2 and 2-3 accumulator pistons, a more robust spiral-lock snap ring, and a staked retainer for the intermediate clutch. Poor performance with DTCs P0715, P0716 & P0717 – 4R100 Transmission Common Problems with the F250 5R110W Transmission (2003-2010)The Ford 5R110W TorqShift transmission is a five-speed automatic transmission that replaced the aging 4-speed 4R100 transmission. Although it was considered to be a 5-speed automatic, it actually had a 6th overdrive ratio that allowed for an alternate shift pattern in cold weather. At temperatures below 5°F, 5th gear would be skipped in order to increase engine RPM and bring the transmission up to operating temperature. The Ford 5R110W transmission also had full electronic controls, which allowed the computer to lockup the torque converter when the 5R110W Tow/Haul Mode or PTO was in use. Some of the highlights included an integrated trailer brake control system, and the optional Torqshift 5R110W transmission which was fitted with a groundbreaking Tow/Haul Mode that minimized upshifts to keep the engine in the power band, and automatically downshifted to provide engine braking when descending a hill. The Ford 5R110W transmission could also be outfitted with a PTO to power accessories like a snowplow or external hydraulics. 1) Reverse Planetary Assembly A common 5R110W transmission problem has to do with the low/reverse planetary gear pinions. An OE design flaw allowed the gear set pinion shafts to back themselves out of the carrier, resulting in slipping, and harsh or delayed forward/reverse gear engagement. 2) Transmission Pump The Ford F-250 / F-350 5R110W transmission transfers engine power to the wheels through hydraulic pressure. This pressure is created by the transmission pump, which has a tendency to fail prematurely. If this happens, you’ll experience a pronounced delay in forward and reverse gear engagement, or the transmission could just “slam” into gear. Can I drive with a transmission problem?Okay, if your truck can still make it up and down the road, you might say “It’s fine, I’ll just drive it until I can get it fixed”. But that is not always a good idea. You see, there are a lot of (very expensive) moving parts inside of a transmission, and if something isn’t right, continuing to drive with a transmission problem could damage something else. How often does a F250 transmission need to be replaced?The overall lifespan of a Ford F-250 transmission largely depends on how well it was maintained. Factory design flaws also factor into this equation, along with how/how hard you drive. But on average, we’ve seen the OE Ford F-250 5R110W transmission last for between 130,000-220,000 miles. A high quality replacement Ford 5R110W transmission however, can last considerably longer if all of the factory design flaws have been addressed and the vehicle has been maintained. How are Ford F250 SD transmission issues diagnosed?It is fairly easy to guesstimate what the root cause of your Ford F250 transmission problems might be, but you won’t truly know unless you have the right tools and experience. A good mechanic or transmission repair center will be able to connect your Ford Super Duty to a computer and find out which diagnostic trouble codes (DTC’s) have been stored. Once they know what to look for, they can perform a visual inspection to verify the problem. How is a Ford F250 transmission replaced?In order to replace your Ford F-250 transmission, the truck has to be lifted from the ground in order to gain access to all of the parts that will need to be unbolted. Then the transmission can be lowered to the ground (typically with a transmission jack), so the new 5R110W transmission can be installed. Once it is in place, the ECU will have to be reprogrammed to accept the new gearbox. Recommendations for F250 transmission issues?To save time and get back on the road faster, you can get an online quote for a replacement Ford F-250 transmission here, then find a local shop using our Find a Shop guide to install it for you. How to Solve Ford F250 Transmission ProblemsSolution A: Buy a Used Ford F250 Transmission The quickest way to fix your transmission problems is to simply buy a used 4R100 transmission or used 5R110W transmission. These can be found at most junk yards, and they often come with a 30-90 day warranty. However, there’s no way to determine the actual condition of the internal components, so you could be spending a bunch of money to have the exact same problems. Plus, that warranty only covers the transmission if it’s defective, not the labor costs that you’ll have to pay. Solution B: Buy a Rebuilt Ford F250 Transmission Another option would be a rebuilt 4R100 transmission or rebuilt 5R110W transmission. A local repair shop will remove your F250 transmission, then install a bunch of new parts. The problem here is, the skills and experience of each mechanic will vary widely from shop to shop, so you could have problems from something that wasn’t adjusted properly. And the 1-2 year warranty might only cover you at certain transmission repair shops, in a specific geographical area. Solution C: Buy a Remanufactured Ford F250 Transmission Need a replacement transmission? Get an estimate for replacement transmissions and local installation. Look up your transmission model by vehicle make and model. What Transmission Do I Have?Many owners depend on their Ford F-250 to make a living and get things done. Their gasoline and PowerStroke diesel engines are designed to go 100’s of thousands of miles, so it makes sense to invest in a remanufactured 4R100 transmission or remanufactured 5R110W transmission. What transmission does a 98 F250 have?Used 1998 Ford F-250 Specs & Features. Did Ford make a 4Introduced in 1980, it was Ford's first four-speed automatic overdrive transmission. The gearset design is based on the Ford "X" automatic transmissions used during the 1950s, '60s, and '70s.
How much does it cost to replace a transmission on a Ford F250?Generally speaking, a Ford F250 transmission replacement will cost between $6,000 and $6,450, but the exact price will largely depend on the model year, cab-type, and style. The parts associated with a Ford F250 transmission replacement usually cost between $4,300 and $4,650, or roughly 72% of the total service cost.
What transmission does the F250 have?The standard engine for 2018 is a 6.2-liter V8 with 385 horsepower and 430 lb-ft of torque. You can also get the 6.7 turbo-diesel V8 making 440 horsepower and 925 lb-ft of torque. Both engines mate to a six-speed automatic transmission.
|